Chevrolet G20 1995 Recalls

JUL 19, 1999

1995 CHEVROLET G20

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: CERTAIN LIGHT DUTY PICKUP TRUCKS, SPORT UTILITY VEHICLES, OR MINIVANS EQUIPPED WITH 3-SENSOR ABS (ANTILOCK BRAKING SYSTEM) EBC4 UNITS.

THESE VEHICLES CAN EXPERIENCE EXTENDED STOPPING DISTANCES DURING ABS STOPS ON CERTAIN MULTIPLE SURFACES, INCREASING THE RISK OF A CRASH.

DEALERS WILL MODIFY THE COMPUTER PROGRAM WHICH OPERATES THE ABS UNIT ON SOME VEHICLES, OR REPLACE THE COMPUTER ON OTHERS TO IMPROVE THE PERFORMANCE OF THE ABS ON THESE SURFACES.

2400000

GENERAL MOTORS CORP.

MAY 19, 1999

1995 CHEVROLET G20

VEHICLE DESCRIPTION: CHEVROLET AND GMC G VANS EQUIPPED WITH SLIDING SIDE DOORS AND REMEDIED DURING SAFETY CAMPAIGN (95V197/95-C-58) BETWEEN JULY 18, 1997 AND FEBRUARY 6, 1999. THE SLIDING SIDE-DOOR REAR LATCH WAS REPLACED WITH A LATCH THAT WAS IMPROPERLY RIVETED.

IN THE EVENT OF A VEHICLE CRASH, THE DOOR MAY NOT PERFORM AS REQUIRED AND INCREASED INJURIES COULD RESULT.

DEALERS WILL REPLACE THE SLIDING DOOR REAR LATCH.

282

GENERAL MOTORS CORP.

OCT 17, 1995

1995 CHEVROLET G20

THESE VEHICLES WERE BUILT WITH A SLIDING SIDE-DOOR REAR LATCH THAT WAS IMPROPERLY RIVETED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."

CONSEQUENCE OF NON-COMPLIANCE: IN THE EVENT OF A VEHICLE CRASH, THE DOOR WILL NOT PERFORM AS REQUIRED BY THE STANDARD.

DEALERS WILL REPLACE THE SLIDING DOOR REAR LATCH ON ALL SUSPECT VEHICLES.

936

GENERAL MOTORS CORP.

NOV 21, 1994

1995 CHEVROLET G20

BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) CAUTION LABEL AND AN ENGINE START LABEL WERE INSTALLED ON THE SAME SIDE OF THE DRIVER'S SUN VISOR. THIS DOES NOT COMPLY WITH FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."

CONSEQUENCE OF NON-COMPLIANCE: OPERATORS COULD FAIL TO NOTICE AND HEED THE WARNING LABELS.

A NEW LABEL, WITH INSTALLATION INSTRUCTIONS, WILL BE SENT DIRECTLY TO OWNERS. OWNERS WILL INSTALL THE LABEL OR CAN HAVE THEIR DEALER INSTALL THE LABEL FOR THEM.

185

GENERAL MOTORS CORP.

MAY 19, 2006

1995 CHEVROLET G20

CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK ON "DOCUMENT SEARCH" AND THEN "BUS APPLICATIONS"). THE CONNECTOR ON THE FUEL FILTER WAS NOT MANUFACTURED TO HONEYWELL'S SPECIFICATION. AS A RESULT, THE O-RING MAY NOT SEAT CORRECTLY ON THE FUEL LINE.

THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.

HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).

88303

HONEYWELL INTERNATIONAL, INC.

OCT 24, 2007

1995 CHEVROLET G20

CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.

THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.

HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.

121680

HONEYWELL INTERNATIONAL, INC.