| Recall Date: |
AUG 23, 2002 |
| Component: |
FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS |
| Model Affected: |
TRAILBLAZER |
| Units Affected: |
136511
Recall Details
|
Recall Date:
AUG 23, 2002
Model Affected:
2002 CHEVROLET TRAILBLAZER
Summary:
ON CERTAIN SPORT UTILITY VEHICLES, A FUEL FILTER FITTING CAN BECOME DISCONNECTED. IF THIS WERE TO OCCUR WHILE ATTEMPTING TO START THE ENGINE, A NO-START CONDITION WOULD RESULT AND FUEL WOULD BE PUMPED OUT THE FUEL FILTER ONTO THE GROUND.
Consequence:
IF THE FITTING BECOMES DISCONNECTED WHILE THE VEHICLE IS IN MOTION, THE ENGINE WOULD STOP DUE TO INADEQUATE FUEL SUPPLY AND CAUSE A LOSS OF POWER STEERING ASSIST. IF AN IGNITION SOURCE WERE PRESENT, FUEL LEAKAGE FROM A DISCONNECTED FUEL FILTER FITTING COULD RESULT IN A FIRE.
Remedy:
DEALERS WILL REPLACE THE FUEL FILTER QUICK CONNECT RETAINERS. OWNER NOTIFICATION BEGAN SEPTEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020. GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Units Affected:
136511
Notes:
GENERAL MOTORS CORP.
| Recall Date: |
AUG 09, 2002 |
| Component: |
AIR BAGS:FRONTAL |
| Model Affected: |
TRAILBLAZER |
| Units Affected: |
133221
Recall Details
|
Recall Date:
AUG 09, 2002
Model Affected:
2002 CHEVROLET TRAILBLAZER
Summary:
CERTAIN PASSENGER, MINI VANS, AND SPORT UTILITY VEHICLES HAVE AN AIR BAG INFLATOR ON THE DRIVER'S SIDE THAT COULD FRACTURE AT A WELD DURING A DEPLOYMENT.
Consequence:
PIECES OF THE INFLATOR COULD STRIKE AND INJURE VEHICLE OCCUPANTS AND THE AIR BAG CUSHION WOULD NOT INFLATE FULLY, REDUCING THE CAPABILITY OF THE BAG TO PROTECT THE DRIVER.
Remedy:
DEALERS WILL INSPECT, AND REPLACE, IF NECESSARY, THE AIR BAG MODULE ASSEMBLY ON THE DRIVER'S SIDE. OWNER NOTIFICATION BEGAN AUGUST 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT BUICK AT 1-800-521-7300, CADILLAC AT 1-800-458-8006, CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR PONTIAC AT 1-800-762-2737.
Units Affected:
133221
Notes:
GENERAL MOTORS CORP. 02032
| Recall Date: |
SEP 05, 2001 |
| Component: |
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) |
| Model Affected: |
TRAILBLAZER |
| Units Affected: |
895
Recall Details
|
Recall Date:
SEP 05, 2001
Model Affected:
2002 CHEVROLET TRAILBLAZER
Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES (4 WHEEL-DRIVE). SOME OF THESE VEHICLES WERE BUILT WITH A RANGE SHIFT COLLAR IN THE TRANSMISSION TRANSFER CASE THAT CONTAINS CRACKS.
Consequence:
THIS CONDITION COULD RESULT IN A COMPLETE FRACTURE OF THE RANGE SHIFT COLLAR AND SUBSEQUENT LOSS OF VEHICLE FORWARD AND REVERSE GEARS, AND THE INABILITY TO MAINTAIN "PARK" POSITION. THIS INCREASES THE RISK OF A VEHICLE CRASH RESULTING FROM UNINTENDED MOVEMENT OF A PARKED VEHICLE.
Remedy:
DEALERS WILL REPLACE THE TRANSFER CASES AND UPDATE THE CONTROL MODULE CALIBRATION. OWNER NOTIFICATION BEGAN SEPTEMBER 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Units Affected:
895
Notes:
GENERAL MOTORS CORP. 01061
| Recall Date: |
OCT 04, 2002 |
| Component: |
STRUCTURE:BODY |
| Model Affected: |
TRAILBLAZER |
| Units Affected: |
46
Recall Details
|
Recall Date:
OCT 04, 2002
Model Affected:
2002 CHEVROLET TRAILBLAZER
Summary:
CERTAIN SPORT UTILITY VEHICLES ARE MISSING WELDS ON THE REAR FLOOR PLAN.
Consequence:
IN A CRASH, MISSING WELDS COULD DEGRADE PERFORMANCE OF THE THIRD ROW SEAT AND SAFETY BELT ANCHORAGE AND OCCUPANTS COULD RECEIVE GREATER INJURIES.
Remedy:
DEALERS WILL INSPECT THE VEHICLE FOR MISSING WELDS. IF MISSING WELDS ARE FOUND, GM WILL EXCHANGE THE VEHICLE FOR AN EQUIVALENT VEHICLE OR PROVIDE A REFUND OF THE PURCHASE PRICE. OWNER NOTIFICATION BEGAN OCTOBER 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Units Affected:
46
Notes:
GENERAL MOTORS CORP. 02045
| Recall Date: |
OCT 17, 2001 |
| Component: |
POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE) |
| Model Affected: |
TRAILBLAZER |
| Units Affected: |
78004
Recall Details
|
Recall Date:
OCT 17, 2001
Model Affected:
2002 CHEVROLET TRAILBLAZER
Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES EQUIPPED WITH 4-WHEEL DRIVE. THE CALIBRATION OF THE TRANSFER CASE CONTROL MODULE COULD CAUSE INSUFFICIENT HIGH SPEED GEAR ENGAGEMENT.
Consequence:
IF THE GEAR IS NOT ENGAGED, THE VEHICLE CAN ROLL WHEN THE TRANSMISSION IS IN "PARK" AND A CRASH COULD RESULT WITHOUT WARNING.
Remedy:
DEALERS WILL UPDATE THE TRANSFER CASE CONTROL MODULE CALIBRATION TO INCREASE GEAR ENGAGEMENT. OWNER NOTIFICATION BEGAN NOVEMBER 6, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020 OR GMC AT 1-800-462-8782.
Units Affected:
78004
Notes:
GENERAL MOTORS CORP. 01064/01065
| Recall Date: |
APR 12, 2001 |
| Component: |
SUSPENSION:FRONT:CONTROL ARM:LOWER ARM |
| Model Affected: |
TRAILBLAZER |
| Units Affected: |
30476
Recall Details
|
Recall Date:
APR 12, 2001
Model Affected:
2002 CHEVROLET TRAILBLAZER
Summary:
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER CERTAIN CIRCUMSTANCES THE FRONT LOWER CONTROL ARM BRACKETS MAY FRACTURE. THIS FRACTURE COULD RESULT IN SEPARATION OF THE FRONT LOWER CONTROL ARM FROM THE FRAME.
Consequence:
A SEPARATION COULD RESULT IN LOSS OF VEHICLE CONTROL, RESULTING IN A CRASH.
Remedy:
DEALERS WILL REPLACE THE LEFT AND RIGHT FRONT LOWER CONTROL ARM BRACKETS. OWNER NOTIFICATION BEGAN BY TELEPHONE ON APRIL 4, 2001. THE FOLLOWUP LETTER TO CONSUMERS WAS MAILED MAY 3, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, OLDSMOBILE AT 1-800-442-6537, OR GMC AT 1-800-462-8782.
Units Affected:
30476
Notes:
GENERAL MOTORS CORP. 01034
| Recall Date: |
MAR 06, 2003 |
| Component: |
POWER TRAIN:AUTOMATIC TRANSMISSION |
| Model Affected: |
TRAILBLAZER |
| Units Affected: |
511167
Recall Details
|
Recall Date:
MAR 06, 2003
Model Affected:
2002 CHEVROLET TRAILBLAZER
Summary:
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 114, "THEFT PROTECTION." THESE VEHICLES ARE EQUIPPED WITH A MECHANICAL OVERRIDE THAT COULD ALLOW THE IGNITION KEY TO BE REMOVED WITH THE SHIFT LEVER IN A POSITION OTHER THAN PARK. IN ADDITION, THESE VEHICLES HAVE AN OVERRIDE THAT CAN ALLOW THE TRANSMISSION TO BE SHIFTED OUT OF PARK WITH THE IGNITION IN THE OFF POSITION.
Consequence:
THESE OVERRIDES ARE NOT PERMITTED UNLESS THE VEHICLE HAS A LOCKING STEERING COLUMN.
Remedy:
DEALERS WILL ELIMINATE THESE CONDITIONS BY DISABLING THE OVERRIDES. OWNER NOTIFICATION BEGAN ON MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OLDSMOBILE AT 1-800-442-6537, OR HUMMER AT 1-866-486-6376.
Units Affected:
511167
Notes:
GENERAL MOTORS CORP. 03012
| Recall Date: |
MAR 19, 2003 |
| Component: |
ELECTRICAL SYSTEM:WIRING:INTERIOR/UNDER DASH |
| Model Affected: |
TRAILBLAZER |
| Units Affected: |
314300
Recall Details
|
Recall Date:
MAR 19, 2003
Model Affected:
2002 CHEVROLET TRAILBLAZER
Summary:
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARDS NO. 101, "CONTROL LOCATION, IDENTIFICATION, AND ILLUMINATION" AND NO. 208, "OCCUPANT CRASH PROTECTION." THESE VEHICLES HAVE AN INTERMITTENT CONDITION DURING VEHICLE START-UP IN WHICH THE INSTRUMENT PANEL CLUSTER MAY NOT PROPERLY POWER UP, RESULTING IN MOST OF THE DISPLAYS, TELLTALE LIGHTS, AND FUNCTIONS (EXCEPT THE SERVICE ENGINE LIGHT, TURN SIGNAL INDICATORS, AND THE INSTRUMENT PANEL CLUSTER BACKLIGHTING) BEING INOPERATIVE.
Consequence:
THESE VEHICLES DO NOT COMPLY WITH THE STANDARD.
Remedy:
DEALERS WILL REPROGRAM THE INSTRUMENT PANEL CLUSTER. OWNER NOTIFICATION BEGAN MAY 29, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Units Affected:
314300
Notes:
GENERAL MOTORS CORP. 03013
| Recall Date: |
JUL 15, 2003 |
| Component: |
EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL |
| Model Affected: |
TRAILBLAZER |
| Units Affected: |
1707825
Recall Details
|
Recall Date:
JUL 15, 2003
Model Affected:
2002 CHEVROLET TRAILBLAZER
Summary:
CERTAIN MINIVANS, PASSENGER AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEM." THE OWNER'S MANUAL DOES NOT EXPLAIN THE MEANING OF THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT LOWER UNIVERSAL ANCHORAGE SYSTEM.
Consequence:
THIS DOES NOT MEET THE REQUIREMENTS OF THE STANDARD.
Remedy:
OWNERS WILL BE PROVIDED WITH A SUPPLEMENT FOR THEIR OWNER'S MANUAL. THIS SUPPLEMENT DESCRIBES AND SHOWS THE LOCATION SYMBOLS FOR THE CHILD RESTRAINT ANCHORS THAT ARE LOCATED IN THE VEHICLE AND ON THE CHILD RESTRAINT OR BOOSTER CUSHION. OWNER NOTIFICATION BEGAN AUGUST 18, 2003. OWNERS SHOULD CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668, OR OLDSMOBILE AT 1-800-630-6537.
Units Affected:
1707825
Notes:
GENERAL MOTORS CORP. 03039
| Recall Date: |
NOV 01, 2004 |
| Component: |
EXTERIOR LIGHTING:BRAKE LIGHTS |
| Model Affected: |
TRAILBLAZER |
| Units Affected: |
871473
Recall Details
|
Recall Date:
NOV 01, 2004
Model Affected:
2002 CHEVROLET TRAILBLAZER
Summary:
ON CERTAIN SPORT UTILITY VEHICLES, VIBRATION AND HEAT MAY CAUSE THE TAIL LAMP/STOP LAMP BULB TO LOOSEN IN ITS SOCKET. IF THIS OCCURS, THE BULB MAY FLICKER AND EVENTUALLY BECOME INOPERATIVE.
Consequence:
AN INOPERATIVE BRAKE LAMP WILL NOT CONVEY THE DRIVER'S INTENTION OF STOPPING TO DRIVERS IN FOLLOWING VEHICLES, AND AN INOPERATIVE REAR TURN SIGNAL LAMP WILL NOT CONVEY THE DRIVER'S INTENTION TO TURN TO DRIVERS IN FOLLOWING VEHICLES. BOTH OF THESE FAILURES CAN INCREASE THE RISK OF A CRASH.
Remedy:
DEALERS WILL INSPECT THE TAIL LAMP/STOP LAMP ASSEMBLIES, AND IF NECESSARY, REPLACE THEM. THE RECALL BEGAN ON NOVEMBER 22, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, BUICK AT 1-866-608-8080, OR GMC AT 1-866-996-9463.
Units Affected:
871473
Notes:
GENERAL MOTORS CORP. 04087
| Recall Date: |
APR 28, 2004 |
| Component: |
SEAT BELTS |
| Model Affected: |
TRAILBLAZER |
| Units Affected: |
261801
Recall Details
|
Recall Date:
APR 28, 2004
Model Affected:
2002 CHEVROLET TRAILBLAZER
Summary:
CERTAIN LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." ONE OF THE TWO SENSORS IN THE DRIVER'S AND FRONT PASSENGER'S SEAT BELT RETRACTORS COULD BE INOPERATIVE. THE SEAT BELT RETRACTORS WILL LOCK WHEN THE BELT WEBBING IS EXTRACTED DURING A CRASH; HOWEVER, THE MECHANISM THAT LOCKS THE SEAT BELT RETRACTOR WHEN THE VEHICLE DECELERATES QUICKLY, SUCH AS HEAVY BRAKING, MAY NOT OPERATE AS INTENDED.
Consequence:
IF THIS WERE TO OCCUR, THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, AND COULD RESULT IN INJURY TO THE OCCUPANT.
Remedy:
DEALERS WILL INSPECT THE DRIVER AND FRONT PASSENGER SAFETY BELT RETRACTORS, AND REPLACE THEM IF NECESSARY. OWNER NOTIFICATION BEGAN ON JUNE 24, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537.
Units Affected:
261801
Notes:
GENERAL MOTORS CORP. 04037
| Recall Date: |
FEB 04, 2004 |
| Component: |
VISIBILITY:WINDSHIELD WIPER/WASHER |
| Model Affected: |
TRAILBLAZER |
| Units Affected: |
581394
Recall Details
|
Recall Date:
FEB 04, 2004
Model Affected:
2002 CHEVROLET TRAILBLAZER
Summary:
CERTAIN SPORT UTILITY VEHICLES HAVE WINDSHIELD WIPER SYSTEMS THAT WILL NOT TURN ON, CEASE OPERATION WHILE IN USE, FAIL TO TURN OFF/ON BY THEMSELVES (MOISTURE SENSITIVE WIPER SYSTEM), OR HAVE CONTINUOUS WINDSHIELD WASHER PUMP OPERATION BECAUSE THE PRESENCE OF WATER WITHIN THE WIPER MODULES CAN EITHER CAUSE A SHORT CIRCUIT OR CAN LEAD TO THE CORROSION OF COMPONENTS WITHIN THE MODULE.
Consequence:
DEPENDING ON THE OCCURRENCE AND WEATHER SITUATION, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy:
DEALERS WILL COVER THE WINDSHIELD WIPER MODULE VENT HOLE WITH A PATCH. ALSO, THE WIPER MOTOR, CIRCUIT BOARD, AND ELECTRICAL CONNECTOR WILL BE INSPECTED TO SIGNS OF WATER INTRUSION AND/OR CORROSION AND BE REPLACED AS REQUIRED. THE RECALL BEGAN JULY 6, 2004. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; OLDSMOBILE AT 1-800-630-6537; OR GMC AT 1-866-996-9463.
Units Affected:
581394
Notes:
GENERAL MOTORS CORP. 04005
| Recall Date: |
MAR 21, 2006 |
| Component: |
EXTERIOR LIGHTING:HEADLIGHTS |
| Model Affected: |
TRAILBLAZER |
| Units Affected: |
1450
Recall Details
|
Recall Date:
MAR 21, 2006
Model Affected:
2002 CHEVROLET TRAILBLAZER
Summary:
CERTAIN POLI-AUTO COMBINATION HEADLAMP ASSEMBLIES, P/NOS. 11-728, 11-728D, 11-710, 11-419, 11-713, 11-703, 11-704, 11-708P, 11-735, 11-725, 11-726, 11-716 (P&C), 11-721-1, 11-733, 11-729, 11-730, AND 11-732, SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy:
POLI-AUTO WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE HEADLAMPS AT ITS ORIGINAL PURCHASE PRICE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2006. OWNERS MAY CONTACT POLI-AUTO AT 305-477-1356.
Units Affected:
1450
Notes:
POLI-AUTO, INC.