| Recall Date: |
MAY 17, 2005 |
| Component: |
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT |
| Model Affected: |
TUNDRA |
| Units Affected: |
768379
Recall Details
|
Recall Date:
MAY 17, 2005
Model Affected:
2004 TOYOTA TUNDRA
Summary:
ON CERTAIN SPORT UTILITY VEHICLES, DUE TO A MANUFACTURING ISSUE IN THE FRONT SUSPENSION LOWER BALL JOINT, THERE IS A POSSIBILITY THAT THE SURFACE OF THE BALL OF THE JOINT MAY HAVE BEEN SCRATCHED. THE BALL JOINT MAY EVENTUALLY EXPERIENCE EXCESSIVE WEAR AND LOOSENESS, RESULTING IN INCREASED STEERING EFFORT.
Consequence:
THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE CAUSING LOSS OF STEERING CONTROL AND A CRASH COULD OCCUR.
Remedy:
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON JULY 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Units Affected:
768379
Notes:
TOYOTA MOTOR NORTH AMERICA, INC. 50J
| Recall Date: |
MAR 30, 2005 |
| Component: |
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM |
| Model Affected: |
TUNDRA |
| Units Affected: |
5726
Recall Details
|
Recall Date:
MAR 30, 2005
Model Affected:
2004 TOYOTA TUNDRA
Summary:
CERTAIN PICKUP TRUCKS EQUIPPED WITH BOTH VEHICLE STABILITY CONTROL (VSC) AND THE TRD DUAL EXHAUST SYSTEMS. THE TRD DUAL EXHAUST SYSTEM MET ALL CLEARANCE SPECIFICATIONS ON MODELS WITHOUT VSC, HOWEVER THE DRIVER'S SIDE EXHAUST LOCATED IN A POSITION WHERE CONTACT BETWEEN A BRAKE LINE FOUND ONLY ON VEHICLES WITH VSC AND THE TRD EXHAUST PIPE MIGHT OCCUR.
Consequence:
IN THIS CONDITION, THE EXHAUST PIPE FLANGE MAY RUB AGAINST THE RIGHT REAR BRAKE LINE, WHICH COULD CAUSE BRAKE FLUID LEAKAGE. THIS COULD LEAD TO AN INCREASE OF VEHICLE STOPPING DISTANCE, WHICH COULD RESULT IN A CRASH.
Remedy:
DEALERS WILL INSPECT AND, IF SO EQUIPPED, WILL REPLACE THE TRD DUAL EXHAUST SYSTEM FREE OF CHARGE. DURING THIS REPLACEMENT, THE DEALER WILL ALSO INSPECT THE SPECIFIC BRAKE LINE TO ASSURE IT HAS NOT BEEN DAMAGED AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON MAY 31, 2005. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Units Affected:
5726
Notes:
TOYOTA MOTOR NORTH AMERICA, INC. 50E
| Recall Date: |
MAR 23, 2006 |
| Component: |
EXTERIOR LIGHTING |
| Model Affected: |
TUNDRA |
| Units Affected: |
61944
Recall Details
|
Recall Date:
MAR 23, 2006
Model Affected:
2004 TOYOTA TUNDRA
Summary:
CERTAIN PRO-A MOTORS CORNER LAMPS, TURN SIGNALS, AND HEADLIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON CERTAIN PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy:
PRO-A MOTORS WILL NOTIFY OWNERS AND OFFER TO REPURCHASE THE LAMPS. THE RECALL BEGAN ON APRIL 3, 2006. OWNERS MAY CONTACT PRO-A MOTORS AT 323-838-2988.
Units Affected:
61944
Notes:
PRO-A MOTORS, INC.
| Recall Date: |
MAY 24, 2006 |
| Component: |
EXTERIOR LIGHTING |
| Model Affected: |
TUNDRA |
| Units Affected: |
27176
Recall Details
|
Recall Date:
MAY 24, 2006
Model Affected:
2004 TOYOTA TUNDRA
Summary:
CERTAIN CK MOTORSPORTS COMBINATION HEADLIGHTS, CLEAR CORNER, BUMPER, AND SIDE MARKER LIGHTS SOLD AS REPLACEMENT LAMPS FOR USE ON THE PASSENGER VEHICLES LISTED ABOVE. SOME COMBINATION LAMPS THAT ARE NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence:
WITHOUT THE AMBER REFLECTORS, THE VEHICLE WILL BE POORLY ILLUMINATED, POSSIBLY RESULTING IN A VEHICLE CRASH WITHOUT WARNING.
Remedy:
CK MOTORSPORT WILL NOTIFY OWNERS AND REPLACE THE NONCOMPLIANT LAMPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 1, 2006. OWNERS MAY CONTACT CK MOTORSPORT AT 1-909-610-7211.
Units Affected:
27176
Notes:
CK MOTORSPORT, INC.
| Recall Date: |
JUN 02, 2005 |
| Component: |
AIR BAGS:ON-OFF SWITCH ASSEMBLY |
| Model Affected: |
TUNDRA |
| Units Affected: |
156111
Recall Details
|
Recall Date:
JUN 02, 2005
Model Affected:
2004 TOYOTA TUNDRA
Summary:
CERTAIN PICKUP TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 225, 'CHILD RESTRAINT ANCHORAGE SYSTEMS.' THESE VEHICLES HAVE A MANUAL AIR BAG ON-OFF SWITCH TO DISABLE THE FRONT PASSENGER AIR BAG AND DO NOT HAVE A CHILD RESTRAINT LOWER ANCHORAGE SYSTEM IN THE FRONT PASSENGER SEAT. THIS SPECIFICATION DOES NOT MEET THE STANDARD REQUIREMENTS.
Consequence:
THIS STANDARD ESTABLISHES REQUIREMENTS FOR CHILD RESTRAINT ANCHORAGE SYSTEMS TO ENSURE THEIR PROPER LOCATION AND STRENGTH FOR THE EFFECTIVE SECURING OF CHILD RESTRAINTS, TO REDUCE THE LIKELIHOOD OF THE ANCHORAGE SYSTEMS' FAILURE, AND TO INCREASE THE LIKELIHOOD THAT CHILD RESTRAINTS ARE PROPERLY SECURED AND THUS MORE FULLY ACHIEVE THEIR POTENTIAL EFFECTIVENESS IN MOTOR VEHICLES.
Remedy:
DEALERS WILL REMOVE THE MANUAL AIR BAG ON-OFF SWITCH, REPLACE THE OWNER'S MANUAL, AND AFFIX A NEW SUN VISOR AIR BAG WARNING LABEL. THE RECALL BEGAN IN EARLY JANUARY 2007. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Units Affected:
156111
Notes:
TOYOTA MOTOR NORTH AMERICA, INC. 70A
| Recall Date: |
JUL 17, 2006 |
| Component: |
EXTERIOR LIGHTING |
| Model Affected: |
TUNDRA |
| Units Affected: |
3593
Recall Details
|
Recall Date:
JUL 17, 2006
Model Affected:
2004 TOYOTA TUNDRA
Summary:
CERTAIN AJ MOTORSPORT COMBINATION LAMPS SOLD AS REPLACEMENT LAMPS FOR USE ON THE ABOVE LISTED PASSENGER VEHICLES. COMBINATION LAMPS NOT EQUIPPED WITH AMBER SIDE REFLECTORS FAIL TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence:
LACK OF AMBER SIDE REFLECTORS IN THE LAMPS WILL DECREASE LIGHTING VISIBILITY TO OTHER DRIVERS AND MAY POSSIBLY RESULT IN A VEHICLE CRASH.
Remedy:
AJ MOTORSPORT WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR THE LAMPS. THE RECALL BEGAN ON JULY 31, 2006. OWNERS MAY CONTACT AJ MOTORSPORT AT 626-618-2026.
Units Affected:
3593
Notes:
AJ MOTORSPORT
| Recall Date: |
JAN 19, 2007 |
| Component: |
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT |
| Model Affected: |
TUNDRA |
| Units Affected: |
533124
Recall Details
|
Recall Date:
JAN 19, 2007
Model Affected:
2004 TOYOTA TUNDRA
Summary:
ON CERTAIN TRUCKS AND MINI VANS, DUE TO POSSIBLE IMPROPER FINISHING OF THE FRONT SUSPENSION LOWER BALL JOINT, SOME BALL JOINTS MAY EXPERIENCE AN INCIDENTAL DETERIORATION OF THE INTERNAL LUBRICATION. THIS MAY CAUSE THE BALL JOINT TO WEAR AND LOOSEN PREMATURELY, WHICH COULD RESULT IN INCREASED STEERING EFFORT, REDUCED VEHICLE SELF-CENTERING, AND NOISE IN THE FRONT SUSPENSION.
Consequence:
IN EXTREME CASES, IF THE VEHICLE IS CONTINUOUSLY OPERATED IN THIS CONDITION, THE LOWER BALL JOINT MAY SEPARATE FROM THE KNUCKLE AND COULD CAUSE A LOSS OF VEHICLE CONTROL.
Remedy:
DEALERS WILL REPLACE THE FRONT SUSPENSION LOWER BALL JOINTS. THE RECALL BEGAN ON FEBRUARY 28, 2007. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Units Affected:
533124
Notes:
TOYOTA MOTOR NORTH AMERICA, INC. 70B
| Recall Date: |
MAY 11, 2009 |
| Component: |
EXTERIOR LIGHTING:HEADLIGHTS |
| Model Affected: |
TUNDRA |
| Units Affected: |
42540
Recall Details
|
Recall Date:
MAY 11, 2009
Model Affected:
2004 TOYOTA TUNDRA
Summary:
DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy:
DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
Units Affected:
42540
Notes:
DOPE, INC.