| Recall Date: |
DEC 18, 2007 |
| Component: |
POWER TRAIN:DRIVELINE:DRIVESHAFT |
| Model Affected: |
TUNDRA |
| Units Affected: |
15616
Recall Details
|
Recall Date:
DEC 18, 2007
Model Affected:
2007 TOYOTA TUNDRA
Summary:
ON CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS, DUE TO THE IMPROPER HEAT TREATMENT OF THE SLIP YOKES THAT HAD BEEN REWORKED DURING THE MANUFACTURING PROCESS, THE HARDNESS OF THE SLIP YOKE MAY BE INSUFFICIENT.
Consequence:
IN THIS CONDITION, THERE IS A POSSIBILITY THAT THE YOKE MAY BREAK CAUSING THE PROPELLER SHAFT TO SEPARATE AT THE JOINT AND COME INTO CONTACT WITH THE ROAD SURFACE OR THE FUEL TANK WHICH COULD RESULT IN A LOSS OF VEHICLE CONTROL OR A FUEL LEAK.
Remedy:
DEALERS WILL INSPECT THE SLIP YOKE AND REPLACE THE PROPELLER SHAFT IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 7, 2008. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Units Affected:
15616
Notes:
TOYOTA MOTOR NORTH AMERICA, INC. 70G
| Recall Date: |
MAR 31, 2008 |
| Component: |
WHEELS:LUGS/NUTS/BOLTS |
| Model Affected: |
TUNDRA |
| Units Affected: |
216
Recall Details
|
Recall Date:
MAR 31, 2008
Model Affected:
2007 TOYOTA TUNDRA
Summary:
SOUTHEAST TOYOTA IS RECALLING ALLOY WHEEL LUG NUTS USED FOR THE 18" DIAMOND FINISH 5-SPOKE ALLOY WHEELS AND 20" PAINTED ALLOY WHEELS WITH 6-DUAL SPOKES SOLD AS AN UPGRADE PACKAGE FOR 2007 TOYOTA TUNDRA MODEL VEHICLES. THE WHEEL NUTS CAN CRACK AND BREAK IF THE WHEELS ARE NOT INSTALLED CAREFULLY OR NOT CAREFULLY TIGHTENED. THIS WHEEL NUT CONDITION COULD OCCUR AT THE TIME OF WHEEL INSTALLATION, TIRE ROTATION, OR SERVICE.
Consequence:
CRACKED OR BROKEN WHEEL NUTS COULD RESULT IN A VEHICLE CRASH.
Remedy:
SOUTHEAST TOYOTA WILL NOTIFY OWNERS AND REPLACE THE WHEEL NUTS WITH A MORE ROBUST WHEEL NUT FREE OF CHARGE. THE RECALL BEGAN ON APRIL 21, 2008. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER LOYALTY DEPARTMENT TOLL-FREE AT 800-301-6859.
Units Affected:
216
Notes:
SOUTHEAST TOYOTA DISTRIBUTORS
| Recall Date: |
FEB 25, 2008 |
| Component: |
WHEELS:LUGS/NUTS/BOLTS |
| Model Affected: |
TUNDRA |
| Units Affected: |
1716
Recall Details
|
Recall Date:
FEB 25, 2008
Model Affected:
2007 TOYOTA TUNDRA
Summary:
SOUTHEAST TOYOTA IS RECALLING 1,555 MY 2007 TUNDRA VEHICLES DUE TO A WHEEL NUT ISSUE. THE RECALLED VEHICLES ARE MY 2007 TUNDRAS EQUIPPED WITH 18" INSTALLED DIAMOND FINISH 5-SPOKE ALLOY WHEELS (OPTION CODE WN1 OR WN4) OR 20" INSTALLED PAINTED ALLOY WHEELS WITH 6 DUAL SPOKES (OPTION CODE WV1 OR WV4). AFFECTED VEHICLES WERE ORIGINALLY SOLD IN FLORIDA, GEORGIA, ALABAMA, NORTH CAROLINA OR SOUTH CAROLINA. WHEN THE VEHICLE WAS PROCESSED AT THE PORT, THE UPGRADED ALLOY WHEELS WERE FASTENED WITH NEW WHEEL NUTS. THE WHEEL NUTS CAN CRACK AND BREAK IF THEY ARE NOT INSTALLED CAREFULLY OR NOT CAREFULLY TIGHTENED. THIS WHEEL NUT CONDITION COULD OCCUR AT THE TIME OF WHEEL INSTALLATION, TIRE ROTATION, OR SERVICE.
Consequence:
IF A VEHICLE'S WHEEL HAS A CRACKED OR BROKEN WHEEL NUT CONDITION AND THE WHEEL BECOMES LOOSE AND FALLS OFF THE VEHICLE WITHOUT WARNING, A CRASH COULD OCCUR.
Remedy:
DEALERS WILL REPLACE THE ATTACHING WHEEL NUTS. THE RECALL BEGAN ON APRIL 18, 2008. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Units Affected:
1716
Notes:
SOUTHEAST TOYOTA DISTRIBUTORS
| Recall Date: |
OCT 05, 2009 |
| Component: |
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL |
| Model Affected: |
TUNDRA |
| Units Affected: |
4445056
Recall Details
|
Recall Date:
OCT 05, 2009
Model Affected:
2007 TOYOTA TUNDRA
Summary:
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence:
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy:
TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Units Affected:
4445056
Notes:
TOYOTA MOTOR NORTH AMERICA, INC. 90L(TOYOTA)/90LG(LEX
| Recall Date: |
JAN 21, 2010 |
| Component: |
VEHICLE SPEED CONTROL:ACCELERATOR PEDAL |
| Model Affected: |
TUNDRA |
| Units Affected: |
2230661
Recall Details
|
Recall Date:
JAN 21, 2010
Model Affected:
2007 TOYOTA TUNDRA
Summary:
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
Consequence:
THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
Remedy:
DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Units Affected:
2230661
Notes:
TOYOTA MOTOR NORTH AMERICA, INC. AOA
| Recall Date: |
FEB 03, 2010 |
| Component: |
EQUIPMENT:OTHER:LABELS |
| Model Affected: |
TUNDRA |
| Units Affected: |
153418
Recall Details
|
Recall Date:
FEB 03, 2010
Model Affected:
2007 TOYOTA TUNDRA
Summary:
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence:
A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy:
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Units Affected:
153418
Notes:
SOUTHEAST TOYOTA DISTRIBUTORS, LLC
| Recall Date: |
JUN 15, 2009 |
| Component: |
EQUIPMENT:OTHER:LABELS |
| Model Affected: |
TUNDRA |
| Units Affected: |
27080
Recall Details
|
Recall Date:
JUN 15, 2009
Model Affected:
2007 TOYOTA TUNDRA
Summary:
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence:
INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy:
TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Units Affected:
27080
Notes:
TOYOTA MOTOR NORTH AMERICA, INC.
| Recall Date: |
FEB 03, 2010 |
| Component: |
EQUIPMENT:OTHER:LABELS |
| Model Affected: |
TUNDRA |
| Units Affected: |
271417
Recall Details
|
Recall Date:
FEB 03, 2010
Model Affected:
2007 TOYOTA TUNDRA
Summary:
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence:
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy:
DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Units Affected:
271417
Notes:
GULF STATES TOYOTA, INC.
| Recall Date: |
MAY 12, 2011 |
| Component: |
TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS |
| Model Affected: |
TUNDRA |
| Units Affected: |
1629
Recall Details
|
Recall Date:
MAY 12, 2011
Model Affected:
2007 TOYOTA TUNDRA
Summary:
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2007-2011 TUNDRA VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 138, "TIRE PRESSURE MONITORING SYSTEMS." THE TPMS ON SOME VEHICLES MAY NOT HAVE BEEN PROPERLY CALIBRATED AND AS A RESULT THE LOW TIRE PRESSURE WARNING LAMP MAY NOT ILLUMINATE SHOULD THE INFLATION PRESSURE IN ONE OR MORE OF THE VEHICLE'S TIRES FALL BELOW THE THRESHOLD FOR WHEN THE LOW TIRE PRESSURE WARNING LAMP SHOULD ILLUMINATE.
Consequence:
DRIVERS WILL NOT RECEIVE A WARNING FROM THE TIRE PRESSURE MONITOR THAT ONE OR MORE TIRES ARE UNDERINFLATED, INCREASING THE RISK THAT THE VEHICLE WILL BE DRIVEN WITH ONE OR MORE UNDERINFLATED TIRES, INCREASING THE RISK OF A TIRE FAILURE THAT MAY LEAD TO A CRASH.
Remedy:
DEALERS WILL RECALIBRATE THE TIRE PRESSURE MONITORING SYSTEM IN ACCORDANCE WITH THE REGULATION FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING JULY 2011. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER ASSISTANCE CENTER TOLL FREE AT 1-800-301-6859, MONDAY THROUGH FRIDAY, 8:30 AM TO 5:00 PM, EASTERN STANDARD TIME.
Units Affected:
1629
Notes:
SOUTHEAST TOYOTA DISTRIBUTORS, LLC